Ford E-Series/Econoline/Club Wagon – Excursion – F-Series (2003 – 2008) OBD1 Codes

Model	Year	Engine identification	System
E·Series/Econoline/Club Wagon 6.0/6.4/7.3L Turbo Diesel	2003·08	VIN position 8 = F/R/P	Ford EEC-V
Excursion 6.O/7.3L Turbo Diesel	2003·07	VIN position 8 = F/P	Ford EEC-V
F·Series 6.O/6.4/7.3L Turbo Diesel	2003-08	VIN position 8 = F/R/P	Ford EEC-V

General information

Malfunction indicator lamp (MIL) will illuminate or flash if certain faults are recorded.
ECM operates in backup mode if sensors fail , to enable vehicle to be driven to repair shop.

Accessing

• Trouble codes can only be displayed by using a Scan Tool connected to the data link connector (DLC):

o E-Series/Econoline/Club Wagon 1
_{o Excursion/F-Series 2}

Erasing

• Trouble codes can only be erased by using a Scan Tool connected to the data link connector (DLC).

Trouble code identification

Scan code	Fault location	Probable cause
PO, P2, UO	Refer to OBO-II trouble code tables	–
P1000	System readiness test not complete	–
P1001	Self-test	–
P1102	Mass air flow (MAF) sensor -signal malfunction	Wiring, MAF sensor, ECM
P1105	Dual alternator upper -malfunction	Wiring, alternator, ECM
P1106	Dual alternator lower -malfunction	Wiring, alternator, ECM
P1107 P1108	Dual alternator lower -circuit malfunction Alternator warning lamp -circuit malfunction	Wiring, alternator, ECM Wiring, alternator (upper), alternator (lower), ECM
P1118	Intake air temperature (IAT) sensor -low input	Wiring, IAT sensor, ECM
P1119	Intake air temperature (IAT) sensor -high input	Wiring, IAT sensor, ECM
P1139	Water in fuel warning lamp -circuit malfunction	Wiring, bulb open circuit, instrument panel, ECM
P1140	Water in fuel	Wiring, fuel filter, fuel/water separator sensor,ECM
P1148	Alternator 2 -circuit malfunction	Wiring, alternator, ECM
P1149	Alternator 2 -high input	Wiring, alternator, ECM
P117A	Engine control module (ECM) -engine oil temperature	Engine overheated, wiring, ECM
P1184	Engine oil temperature (EOT) sensor -out of self-test range	Wiring, EOT sensor, ECM
P1209	Injector control pressure -pressure too high	Oil quality, oil level, oil pressure too high/low, low fuel pressure, fuel pressure regulator control solenoid
P1210	Injector control pressure -pressure too high	Wiring, fuel pressure sensor, ECM
P1211	Injector control pressure -pressure too highllow	Oil quality, oil level, oil pressure too highllow, low fuel pressure, fuel pressure regulator control solenoid
P1212	Fuel pressure sensor -signal too high/low	Oil quality, oil level, oil pressure too highllow, low fuel pressure, fuel pressure sensor, fuel pressure regulator
P1218	Cylinder identification -signal failure	Injector control module, ECM
P1219	Cylinder identification -signal failure	Injector control module, ECM
P1227	Turbocharger (TC) wastegate -pressure high	EGR valve, MAF sensor, TC wastegate actuator, turbocharger
P1228	Turbocharger (TC) wastegate -pressure low	EGR valve, MAF sensor, TC wastegate actuator,turbocharger
P1229	Charge air cooler (CAe) pump -circuit malfunction	Wiring, CAC pump relay, CAC pump
P1247	Turbocharger (TC) boost pressure -pressure low	Wiring, hoses, MAP sensor, ECM
P1248	Turbocharger (TC) boost pressure malfunction	Wiring, hoses, MAP sensor, ECM
P1249	Turbocharger (TC) wastegate -malfunction	Wiring, hoses, TC wastegate regulating valve, TC wastegate actuator, ECM
P1250 P1260	Vehicle immobilizer -malfunction Theft detected -vehicle immobilized	—
P1261	Injector circuit, cylinder 1 -high to low side short	Wiring short circuit
P1262	Injector circuit, cylinder 2 -high to low side short	Wiring short circuit
P1263	Injector circuit, cylinder 3 -high to low side short	Wiring short circuit
P1264	Injector circuit, cylinder 4 -high to low side short	Wiring short circuit
P1265	Injector circuit, cylinder 5 -high to low side short	Wiring short circuit
P1266	Injector circuit, cylinder 6 -high to low side short	Wiring short circuit
P1267	Injector circuit, cylinder 7 -high to low side short	Wiring short circuit
P1268	Injector circuit, cylinder 8 -high to low side short	Wiring short circuit
P1271	Injector circuit, cylinder 1 -high to low side open	Wiring open circuit
P1272 P1273	Injector circuit, cylinder 2 -high to low side openInjector circuit, cylinder 3 -high to low side open	Wiring open circuit Wiring open circuit
P1274	Injector circuit, cylinder 4 -high to low side open	Wiring open circuit
P1275	Injector circuit, cylinder 5 -high to low side open	Wiring open circuit
P1276	Injector circuit, cylinder 6 -high to low side open	Wiring open circuit
P1277	Injector circuit, cylinder 7 -high to low side open	Wiring open circuit
P1278 P1280	Injector circuit, cylinder 8 -high to low side open Fuel pressure sensor -low input	Wiring open circuit Wiring, fuel pressure sensor, ECM
P1281	Fuel pressure sensor -high input	Wiring, fuel pressure sensor, ECM
P1282	Injector control pressure -too high	Wiring, fuel pressure regulator control solenoid
P1283	Fuel pressure regulator control solenoid -circuit malfunction	Wiring open circuit/short circuit to positive
P1284	Self-test not complete -fuel pressure sensorfailure	Wiring, fuel pressure sensor, ECM
P1291	Injector circuit, right cylinder bank -circuit malfunction	High side short circuit to ground/positive, injector(s), injector control module
P1292	Injector circuit, left cylinder bank -circuit malfunction	High side short circuit to ground/positive, injector(s), injector control module
P1293	Injector circuit, right cylinder bank -circuit malfunction	High side open circuit, injector(s), injector control module
P1294	Injector circuit, left cylinder bank -circuit malfunction	High side open circuit, injector(s), injector control module
P1295	Multiple faults, right cylinder bank	Wiring short circuit to ground, injector control module
P1296	Multiple faults, left cylinder bank	Wiring short circuit to ground, injector control module
P1297	Injector circuit -malfunction	Wiring short circuit, injector control module
P1298	Injector control module -internal fault	Injector control module
P1316	Injector control module -trouble code(s) stored	Wiring, injector control module, ECM
P1334	Exhaust gas recirculation (EGR)/throttle position sensor -range/performance problem	Wiring, EGRlthrottle position sensor, ECM
P1335	Exhaust gas recirculation (EGR) valve position sensor range/performance problem	Hose leak/blockage, wiring, EGR valve position sensor, ECM
P1378	Fuel injector control module (FICM) -low input	Fuse, wiring, FICM relay
P1379	Fuel injector control module (FICM) -high input	Wiring, alternator, ECM
P1408	Exhaust gas recirculation (EGR) system -out of self-test range	Wiring, EGR hoses, EGR valve, EGR solenoid, ECM
P1460	Wide open throttle (WOT) relay, AlC -circuit malfunction	Wiring, WOT relay, ECM
P1463	AlC refrigerant pressure sensor -insufficient pressure change	Wiring, AlC system -mechanical fault, AlC refrigerant pressure sensor, AlC compressor clutch
P1464	AlC demand -signal out of self-test range	Wiring, AlC ON -during self-test, WOT relay (AIC cut-out), ECM
P1501 0	Vehicle speed sensor (VSS) -out of self-test range	Wiring, VSS/ABS wheel speed sensors
P1501 f)	Vehicle speed sensor (VSS) -out of self-test range	Electro-magnetic interference
P1502	Diagnostic self-test -communication error	Wiring, ECM
P1531	Accelerator pedal moved during self-test	Repeat test
P1536	Parking brake switch -circuit malfunction	Wiring short circuit to ground/positive, wiring open circuit, low brake fluid
P1610	Engine control module (ECM)	Incorrect programming, ECM
P1611	Engine control module (ECM)	Incorrect programming
P1615	Engine control module (ECM)	Incorrect programming
P1616	Engine control module (ECM) -low input	Incorrect programming
P1617	Engine control module (ECM)	Incorrect programming
P1618	Engine control module (ECM) -low input	Incorrect programming
P1633	‘Keep alive’ power supply -voltage too low	Wiring, ECM
P1635	Tire/axle ratio out of range	Incorrect tire size, incorrect axle ratio, incorrect vehicle 10 configuration
P1636	Engine control module (ECM) -internal fault	ECM
P1639	Engine control module (ECM) -invalid or missing data	Incorrect vehicle 10 configuration, ECM
P1662	Injector control module relay -circuit malfunction	Wiring, fuses, injector control module relay
P1663	Fuel delivery command signal -malfunction	Wiring open circuit/short circuit to ground, injector control module, ECM
P1667	Cylinder identification -circuit malfunction	Wiring open circuit/short circuit to ground, injector control module relay, injector control module,ECM
P1668	Engine control module (ECM)/injector controlmodule -communication error	Wiring open circuit/short circuit to ground, injector control module relay, injector control module,ECM
P1670	Electronic feedback, ECM/injector control module -communication error	Wiring open circuit/short circuit to ground, injector control module relay, injector control module, ECM
P1690	Turbocharger (TC) wastegate regulating valve malfunction	Wiring open circuit/short circuit to ground, turbocharger (TC) wastegate control solenoid,ECM
P1702	Transmission range (TR) sensor -circuit intermittent	Incorrect adjustment, wiring, TR sensor
P1703	Brake pedal position (BPP) switch out of self-testrange	Wiring, BPP switch, ECM
P1704	Transmission range (TR) sensor -malfunction	Incorrect adjustment, wiring, TR sensor
P1705	Transmission range (TR) sensor out of self-test range	Incorrect adjustment, wiring, TR sensor
P1711	Transmission fluid temperature (TFT) sensor out of self-test range	Transmission not at normal operating temperature -repeat test
P1713	Transmission fluid temperature (TFT) sensor low range failure	Wiring, TFT sensor
P1714	Shift solenoid (SS) A -inductive malfunction	Wiring, 55, ECMITCM
P1715	Shift solenoid (SS) B -inductive malfunction	Wiring, 55, ECMITCM
P1718	Transmission fluid temperature (TFT) sensor high range failure	Wiring, TFT sensor
P1725	Insufficient engine speed increase during self-test	Repeat test
P1726	Insufficient engine speed decrease during self-test	Repeat test
P1728	Torque converter clutch (TCC) -slip fault	TCC
P1729	4x4L switch -malfunction	Wiring, four wheel drive shift control module, ECM
P1740	Torque converter clutch (TeC) solenoid -malfunction	Wiring, TCC solenoid, ECMfTCM
P1744	Torque converter clutch (TCC) malfunction	Wiring, TCC, TCM
P1746	Transmission fluid pressure (TFP) solenoid -circuit malfunction	Wiring, TFP solenoid, TCM, ECM
P1747	Transmission fluid pressure (TFP) solenoid -short circuit	Wiring, TFP solenoid, ECM
P1754	Coast/converter clutch solenoid -circuit malfunction	Wiring, coast clutch solenoid
P1760	Transmission fluid pressure (TFP) solenoid -short circuit	Wiring, TFP solenoid, TCM
P1780	Overdrive selection switch	Wiring, transmission control switch, ECM
P1781	4x4L switch -out of self-test range	Wiring, four wheel drive shift control module, 4x4L switch, ECM
P1783	Transmission fluid temperature (TFT) sensoroverheating condition	Wiring, TFT sensor, TCM, ECM